Sterndrive extensions
Tightening torques – see the picture!
The 1" extension
Install the cover over the shift mechanism.
Coat the contact surfaces with a sealant. Use the 3
new O-rings and the oil pipe from the extension kit. In-
stall the extension on the lower gear housing.
If the paint has been damaged, use touch-up paint to
repair. See under Accessories – Aquamatic.
Install the locking ring in the splines sleeve. Turn the
end with locking ring downwards and then install the
sleeve on the lower vertical shaft.
Fill up with lubrication oil. Regarding oil quantity and
oil quality, see chapter Technical Data. Check the oil
level with the sterndrive fully lowered. Let a few min-
utes pass after you have shut down the engine before
you start checking the oil level. Push down the oil dip-
stick as far as possible, however, without tightening it.
Lift up the oil dipstick and register the oil level. Top-up
if necessary.
Install the stud screws ‘D’ in the intermediate housing
‘
E’.
Coat the contact surfaces with a sealant and place
the intermediate housing on the extension.
NOTE! Do not forget the O-rings! Tighten the bolts ‘F’
and nuts ‘G’ (1" extension) evenly and in diagonal se-
quence. Use the existing washers ‘H’ on the nuts. On
the 4" extension the screws ‘K’ and the washers ‘L’
are used instead of nuts and washers.
NOTE! Do not forget the small O-ring underneath the
oil dipstick head.
161
| Categories | Volvo Penta Manuals |
|---|---|
| Tags | Volvo Penta 280, Volvo Penta 280-DP, Volvo Penta 285, Volvo Penta 290, Volvo Penta 290-DP, Volvo Penta DP-A, Volvo Penta DP-B, Volvo Penta DP-C, Volvo Penta SP-A, Volvo Penta SP-C |
| Download File |
|
| Document File Type | |
| Copyright | Attribution Non-commercial |
(9 votes, average: 4.22 out of 5)
Marine readers have rated Volvo Penta 280 285 290 DP SP A B C Workshop Manual 4.2 out of 5.0 based on 9 product reviews. Problem Winther noise when turne
not pulling water so hope I find the info
Kinda a premature review, at this point I am asked to review the manual before ever seeing it?
Great step by step information.
thank you
needed it bad
ok