Repair instructions
Propeller installation
Locking the propeller cone on sterndrives of earlier
manufacture is done by a folding washer and on stern-
drives of later manufacture by a locking screw through
the cone center.
5.
6.
7.
Install the spacer ring (2).
Install and tighten the propeller cone (1).
Install and tighten the center bolt (6).
NOTE! Sterndrive model 290B ratio 1.61:1 is differ-
ent from sterndrive model 290D ratio 2.15:1. The dif-
ference consists of propellers with long and short
hub respectively. See the picture!
Installing a ‘long hub’ type of
propeller (A)
1.
Grease the propeller shaft with a thin layer of
grease.
2.
3.
4.
5.
6.
Install the fishing line deflector (5).
Install the propeller.
NOTE! Short hub propellers (folding washer and cone)
will be replaced by long hub propellers (plastic washer,
cone, center bolt). When installing long hub propellers
on older sterndrives, the propeller shaft must be drilled
and tapped for use of cone with center bolt.
Insert the plastic washer (3).
Install and tighten the propeller cone (1).
Install and tighten the center bolt, (6).
Use drill jigg 885149 to drill the propeller shaft elimi-
nating the need to remove the shaft from the drive unit
as follows:
Installing a ‘short hub’ type of
propeller (B)
1.
2.
Install drill jigg on propeller shaft.
Drill a 6.5 mm (0.255”) hole to a depth of 20 mm
1.
Grease the propeller shaft with a thin layer of
grease.
(0.787”).
ougly.
Use cutting oil to cool shaft. Clean thor-
2.
3.
4.
Install the fishing line deflector (5).
Install the propeller
3.
4.
Use a 5/16”-18 UNC taps to thread shaft. Clean
thorougly.
Insert the plastic washer (3).
Install propeller, plastic washer, cone and center
bolt. Torque: cone = 110 Nm (81 ft.lb.), bolt =
22
Nm (16 ft.lb.).
138
| Categories | Volvo Penta Manuals |
|---|---|
| Tags | Volvo Penta 280, Volvo Penta 280-DP, Volvo Penta 285, Volvo Penta 290, Volvo Penta 290-DP, Volvo Penta DP-A, Volvo Penta DP-B, Volvo Penta DP-C, Volvo Penta SP-A, Volvo Penta SP-C |
| Download File |
|
| Document File Type | |
| Copyright | Attribution Non-commercial |
(9 votes, average: 4.22 out of 5)
Marine readers have rated Volvo Penta 280 285 290 DP SP A B C Workshop Manual 4.2 out of 5.0 based on 9 product reviews. Problem Winther noise when turne
not pulling water so hope I find the info
Kinda a premature review, at this point I am asked to review the manual before ever seeing it?
Great step by step information.
thank you
needed it bad
ok