SERVICE MANUAL NUMBER 23
TROUBLE CODE DIAGNOSTICS - 7.4L MPI
Code 15 (2 of 3): Engine Coolant Temperature (ECT) Sensor Circuit
(Non-Scan) High Temperature Indicated
DIAGNOSTIC AIDS:
Check for the following conditions:
•
•
Poor connection at ECM. Inspect harness connectors for backed out terminals,
improper mating, broken locks, improperly formed or damaged terminals, and poor ter-
minal to wire connection.
Damaged harness. Inspect the wiring harness for damage. If the harness appears to be
OK, observe the ECT display on the scan tool while moving connectors and wiring har-
nesses related to the ECT sensor. A change in the ECT display will indicate the location
of the fault.
•
Check harness routing for a potential short to ground in CKT 410.
After repairs, clear DTC’s following “Clearing Trouble Codes” procedure at the front of this
section. Failure to do so may result in DTC’s not properly being cleared.
TEST DESCRIPTION:
Number(s) below refer to circled number(s) on the diagnostic chart.
Step 2. This step checks if there is a problem with the ECM and wiring or if the problem
is the ECT sensor.
Step 3. Check the harness terminals thoroughly for loose connections. If the resistance
of the ECT sensor is monitored, the resistance should steadily decrease as the engine
coolant warms up. The resistance reading should stabilize when the thermostat opens.
IMPORTANT: If replacing the ECT sensor, tighten hand tight plus 2-1/2 turns maxi-
mum.
STEP
ACTION
VALUE
YES
NO
PROCEED TO
Go to
Was the “On-Board Diagnostic” (OBD) System
Check Performed?
OBD
System
Check
1
2
–
Step 2
1. Ignition “OFF.”
2.
3.
4.
Disconnect ECT sensor harness terminals.
Ignition “ON,” engine “OFF.”
Connect DVOM across the coolant sensor
harness terminals.
Is voltage above the specified value?
4 Volts
Step 3
Step 4
90-861326--1
MARCH 1999
Page 5G-7
| Categories | Mercury MerCruiser Manuals |
|---|---|
| Tags | Mercury MerCruiser 454 CID, Mercury MerCruiser 502 CID |
| Model Year | 1998, 1999, 2000, 2001 |
| Download File |
|
| Document File Type | |
| Copyright | Attribution Non-commercial |
(1 votes, average: 5 out of 5)
Marine readers have rated Mercury MerCruiser GM V8 GM V8 454 CID 7.4L and 502 cid 8.2L Marine Engines Service Manual Number 23 5.0 out of 5.0 based on 1 product reviews. Just need the manual. Wrote review. Can't technically review what I haven't seen yet...