A. Removal of Hub
3.
If the bearings are in good condition, repacking the
grease should be done at this time. Hand pack each
bearing individually using a premium water resis-
tant wheel bearing grease.
The following instructions pertain only to trailers manu-
factured by Four Winns®. To remove the hub to inspect
the bearings and seals, refer to Figure S15 and the fol-
lowing instructions:
C. Hub Reinstallation
1.
2.
Toreinstallhub,reversetheprocedureslistedabove.
It is important to tighten the spindle nut to approxi-
mately 50 ft. lbs. (12" wrench with full hand force).
Loosen the nut then finger tighten.
3.
4.
Replace the cotter.
Whenreinstallingwheel,thefollowingtighteningpro-
cedure is recommended by the manufacturer:
Figure S15: Axle Components
1.
2.
3.
4.
5.
6.
7.
Remove lug nuts.
a.
b.
Place wheel lug nuts on by hand to start.
Remove wheel.
Tighteninitiallyto15-20ft.lbs.(Apply20pounds
ofpressuretowrench12"long)usingcrosstight-
ening sequence. Proceed to finish tightening
to 85 ft. lbs. (Applying 85 pounds of pressure to
wrench 12" long will yield 85 ft. lbs. of torque).
Remove grease cap.
Remove cotter pin.
Unscrew the spindle nut counter clockwise.
Remove spindle washer.
Remove hub from spindle.
c.
Re-torque after first 50 miles of use.
RefertoSectionS-2G foradditionalinformationonwheel
requirements.
B. Bearing/Seal Inspection and Replacement
When inspecting bearings or seals:
1.
Inspect the grease seal for damage, tears, or cracks.
If there is no damage or leakage in not occurring,
the seal is in good condition.
If the seal is torn or cracked, then it should be re-
placed. The seal can be pried out of the hub with a
screw driver. Be sure to replace the seal using the
recommended replacement parts. Parts can be
obtained from your Four Winns® dealer.
2.
When inspecting the bearing, check for corrosion
and wear. If any rust or wear exists on the bearing,
then remove and replace with the recommended
parts listed in the table above.
Candia FS Owner’s Manual
03/00
Section S
Page 13
| Categories | Four Winns Funship Manuals, Four Winns Manuals, Outboard Marine Corporation Manuals |
|---|---|
| Tags | Four Winns Funship 214, Four Winns Funship 234, Four Winns Funship 254 |
| Model Year | 2002 |
| Download File |
|
| Document Type | Owner's Manual |
| Language | English |
| Product Brand | Boats and Cruisers, Four Winns. For support contact your dealer at http://www.fourwinns.com/locate-dealer.aspx |
| Document File Type | |
| Publisher | fourwinns.com |
| Wikipedia's Page | Outboard Marine Corporation |
| Copyright | Attribution Non-commercial |
(1 votes, average: 3 out of 3)
Marine readers have rated 2002 Four Winns Funship 214 234 254 Boat Owners Manual 3.0 out of 3.0 based on 1 product reviews. very good boat i need the specs