Ventilation and Drainage Systems
K - 1 ENGINE COMPARTMENT
VENTILATION
K - 2 HULL DRAINAGE SYSTEMS
A. Transom Drain
All Four Winns stern drive models are equipped
®
with engine compartment ventilation. This system
is designed to meet or exceed the requirements (in
effect at the time of manufacture) of the U.S. Coast
Guard, the National Marine Manufacturers Associa-
tion, and the American Boat and Yacht Council.
A transom drain with plug is provided in the engine
compartment to allow water drainage. When the boat
is out of the water, the boat and trailer should be
positioned so any bilge water accumulation during dry
storage will flow towards the transom.
A. Natural Ventilation System
Be sure the drain plug is securely in place
prior to launching the boat. Upon shipment of
the boat, the drain plug is usually taped to the
steering wheel.
This system includes air intake and exhaust com-
ponents. The exhaust ducting reaches to the lower
bilge area. This provides adequate air movement
while underway and during bilge blower operation.
B. Forced Air Ventilation
B. Bilge Pumps
All Four Winns
®
models are equipped with an electric
Bilge pumps are provided in the bottom of the hull to
remove miscellaneous water accumulations that might
occur during normal boating or weather conditions.
The bilge pump is controlled by the bilge pump switch
on the dash panel. See Section H-3 for a detailed
description of the bilge pump switches.
bilge blower. The bilge blower provides the ventilation
required prior to starting the engines and while at idle.
See Section H - Electrical Systems for blower opera-
tion instructions.
A bilge pump equipped with automatic switch is
standard on most models. As the water level rises, the
automatic float switch will activate the pump.
When leaving the boat unattended for long periods of
time or during excessive rain storms, it is a good idea
to check on the boat for excessive water accumula-
tion. Be sure both the bilge pump and automatic float
switch are operating properly. The operating time of
the bilge pump will be limited to the battery capacity.
Gasoline vapors can explode resulting in injury
or death. Before starting the engine, check
the engine compartment bilge for gasoline or
vapors, and operate blower for four (4) min-
utes, and verify blower operation. Run blower
when vessel is operating below cruising speed.
ALWAYS operate the bilge blower while the
engines are at idle.
C. Engine Ventilation System Maintenance
NOTICE
While at rest, any bilge water accumulation
may flow forward. Therefore, operate the bilge
pump shortly after getting underway and while
the boat is at a substantial running angle. DO
NOT allow bilge water to accumulate. Damage
to the engine or other components may result.
Periodic inspection and cleaning of the ventilation
ducts is necessary to ensure adequate air circulation.
A buildup of leaves, twigs, or other debris can se-
verely reduce ventilation. Be sure bilge water does not
accumulate to a level that would obstruct the ventila-
tion ducts.
Periodically, clean the bilge pump strainers. DO NOT
allow dirt and debris to clog the bilge pump intakes.
Check operation of the bilge pump float switch often
to ensure movement of the switch is not restricted by
debris, portions of the hull, etc.
Blower operation can be tested by placing a hand over
the vents. DO NOT rely on the sound of the blower.
Be sure a substantial amount of air is being exhausted
by the bilge blower. Check the bilge blower system
often, preferably before each cruise.
Wipe up any oil accumulation in the bilge prior to
activation of the bilge pump. Pumping oil overboard
will pollute the water, and is subject to fine.
Should blower noise and vibration be excessive,
loosening the bilge blower mounting screws and then
tightening evenly usually reduces noise considerably.
Ventilation & Drainage Systems - Section K
Owner’s Manual Page 85
| Categories | Four Winns Manuals, Four Winns SL-Series Manuals, Outboard Marine Corporation Manuals |
|---|---|
| Tags | Four Winns SL |
| Model Year | 2008 |
| Download File |
|
| Document Type | Owner's Manual |
| Language | English |
| Product Brand | Boats and Cruisers, Four Winns. For support contact your dealer at http://www.fourwinns.com/locate-dealer.aspx |
| Document File Type | |
| Publisher | fourwinns.com |
| Wikipedia's Page | Outboard Marine Corporation |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)