General Maintenance
R - 1
WINTERIZATION
3. Lower boat onto cradle properly or place boat on
trailer (if applicable). Be sure boat is adequately
supported. The boat should be raised slightly
under the forward supports or trailer tongue to
improve drainage to the transom drain.
A. Prior to Lifting for Winter Lay-up
1.
Pump out the head (dockside discharge), and
be sure the holding tank is empty. Flush the head
holding tank with soap, water and a deodorizer
(e.g., Lysol Liquid™). Add more water if neces-
sary. Have the cleaning solution pumped out.
4. Be sure all the water is completely drained from
the fresh water system. Disconnect all hoses,
check valves, etc. and blow all the water from the
system using very low air pressure. The use of
nontoxic, fresh water system antifreeze is recom-
mended as an alternative to disassembling the
water system. Refer to Section J-7 - System
Maintenance in this manual for information on
winterizing the water system.
2.
Have the fuel tank either full or completely empty.
See the Engine Owner’s manual for recom-
mendations. Also, check with the dry dock opera-
tors for recommendations. If winter storing with a
full fuel tank, gasoline winterizer such as Sta-bil
fuel conditioner, will reduce varnishing,
condensation, etc.
®
5. Winterize the head as recommended by the
head manufacturer. If the boat is equipped with
a holding tank, mix some antifreeze solution and
pour it into the head. Transfer some of the anti-
freeze to the holding tank by flushing the head.
Also, refer to Section J-7 - System Maintenance
for additional information.
NOTICE
If the fuel has been treated with winterizer,
run engines for ten minutes to make sure the
treated fuel is present in all lines and parts
of the engines.
6.
Ensure that all water is removed from the sump
pump, bilge pump and bilge pump lines. Dry the
hull bilge, and self-bailing cockpit drain troughs.
Water freezing in these areas could cause dam-
age. See Section K-3 - Hull Drainage Systems.
3.
Drain water from the fresh water system.
4.
Before winterizing the engine, flush out the system
according to the specific engine owner’s manual.
The engine flush out should be used to clean the
engine of unwanted salt, mud, sludge, etc. which
may have accumulated in the engine cooling
system.
7. Remove the batteries and store in a cool place.
Clean the batteries using clear, clean water. Be
sure the battery has sufficient water and clean
terminals. Keep the batteries charged throughout
the storage period. DO NOT store the batteries
on a concrete floor or other damp or conductive
surface.
5.
6.
Winterize the engine and drive systems as
recommended in the engine owner’s manual
(applies to both gas and diesel systems). Portions
of this winterization procedure may require that
the boat be lifted. Winterization of engine and boat
systems should be performed by qualified service
personnel.
8. Clean the boat interior thoroughly. Vacuum
carpets, and dry clean drapes and upholstery
jackets as necessary.
If the boat is to be lifted or taken off a trailer,
see Section P-7 - Hull Support in this manual
for additional details.
9. Wash exterior fiberglass components, wax lightly.
10. Clean exterior upholstery with hand dish washing
soap and water, rinse, and dry thoroughly.
B. After Lifting
11.
Remove all oxidation from exterior hardware and
apply a light film of moisture - displacing lubricant.
1.
2.
Remove the drain plug.
Thoroughly wash the fiberglass exterior, especially
the hull bottom. Remove as much marine growth
as possible. Wax lightly.
General Maintenance - Section R
Owner’s Manual Page 123
| Categories | Four Winns Manuals, Four Winns SL-Series Manuals, Outboard Marine Corporation Manuals |
|---|---|
| Tags | Four Winns SL |
| Model Year | 2008 |
| Download File |
|
| Document Type | Owner's Manual |
| Language | English |
| Product Brand | Boats and Cruisers, Four Winns. For support contact your dealer at http://www.fourwinns.com/locate-dealer.aspx |
| Document File Type | |
| Publisher | fourwinns.com |
| Wikipedia's Page | Outboard Marine Corporation |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)