Fuel Systems
I - 1
GASOLINE FUEL SYSTEMS
the.amount.of.fuel.spillage..Always.open.the.lid.slowly.
to.allow.air.to.escape..See.Figure.I-1.
Gasoline.fuel.systems.used.in.Four.Winns .boats.are.
®
designed.to.meet.or.exceed.the.requirements.of.the.
U.S..Coast.Guard,.the.National.Marine.Manufacturers.
Association,.and.the.American.Boat.and.Yacht..
Council.in.effect.at.the.time.of.manufacture.
Check.Valve.prevents.
spills.from.fuel.surge.
Baffles allow air ventilation
but.trap.water
Tanks.on.Four.Winns
®
.boats.are.located.forward.of.
Splash Shield sends overflow
from.vent.back.to.tank
the aft bilge compartment below the floor. Please see
specifications included in your owner’s packet for fuel
tank.capacities.or.visit.our.website.at:.
www.fourwinns.com..
NOTICE
Figure I-1: Fuel Fill
Use only clean fuel of the type and grade
recommended by the engine manufacturer.
Engine damage resulting from the use of a
lower octane gasoline is considered misuse
of the engine and will void the engine warranty.
Refer to the section on Gasoline Requirements
in the engine manual for information on octane
specifications.
The gasket seal on the fuel fill cap assists in sealing
when.closed..A.missing.or.damaged.gasket.can.allow.
water.on.the.surrounding.surfaces.to.run.into.the.tank..
Periodically.inspect.the.gasket.and.the.fuel.deck.plate.
for.damage..
DO NOT confuse GAS deck fill plate with
WATER or WASTE deck plates. Deck fill plates
are labeled according to the intended use.
A. System Testing
All.gasoline.fuel.systems.have.been.factory.inspected.
and.pressure.tested.in.accordance.with.regulations..
in.effect.at.the.time.of.manufacture..Additionally,..
each.fuel.tank.must.pass.rigid.tests.and.inspections.
performed.by.the.fuel.tank.manufacturer.
Spilled fuel is a fire hazard. DO NOT overfill
or overflow the tank, or allow fuel spills into
the hull or bilge. If spillage occurs, clean up
immediately and dispose of soiled rags/towels
in a proper container.
Prior.to.taking.delivery,.it.is.important.that.a.full.in-
spection.be.made.of.the.entire.fuel.system.by.the.sell-
ing.dealer..An.entry.on.the.Four.Winns®.Pre-Delivery.
Inspection.Form.portion.of.the.Warranty.Registration.
Card.will.attest.to.the.dealer’s.performance.of.this.
service.
NOTICE
When fueling at a marina, DO NOT overfill.
Fuel may spill into the water.
B. Fuel Fills
Fuel fill deck plates are located either on the aft deck
or.side.decks,.and.are.marked.“GAS”..To.open,.insert.
the.deck.plate.key.into.the.holes.on.the.cap.and.rotate.
counterclockwise..A.bead.chain.connects.the.cap.to.
body.to.help.prevent.loss.overboard..Be.sure.to.utilize.
the.proper.type.and.grade.of.fuel.as.recommended.by.
the.engine.manufacturer..See.Section.I-2.for..
additional.information.
Avoid overboard spills. When tank is almost full
the sound from the fuel vent will change. The
pitch will become higher indicating the tank is
close to being full. Stop pumping fuel into tank.
DO NOT TOP OFF.
After fueling, replace the fill cap, and wash the areas
around the fuel fill plate. Residual fuel left on the deck
and.hull.sides.can.be.dangerous,.and.will.yellow.the.
fiberglass. It will also damage the tape stripes and
logos.
The fuel fill fitting allows for venting below the fill cap.
While the tank is being filled, the air displaced by the
fuel escapes through the fuel fill/vent. This reduces
Fuel Systems - Section I
Owner’s Manual Page
| Categories | Four Winns Manuals, Four Winns Vista Manuals, Outboard Marine Corporation Manuals |
|---|---|
| Tags | Four Winns Horizon 180, Four Winns Horizon 183, Four Winns Horizon 190, Four Winns Horizon 200, Four Winns Horizon 203, Four Winns Horizon 210, Four Winns Horizon 220, Four Winns Horizon 240, Four Winns Horizon 260 |
| Model Year | 2006, 2007, 2008 |
| Download File |
|
| Document Type | Owner's Manual |
| Language | English |
| Product Brand | Boats and Cruisers, Four Winns. For support contact your dealer at http://www.fourwinns.com/locate-dealer.aspx |
| Document File Type | |
| Publisher | fourwinns.com |
| Wikipedia's Page | Outboard Marine Corporation |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)