C. Swivel Jack
G. Tie-downs
Keep.the.swivel.jack.clean.of.dirt,.tar,.and.mud..
Lubricate.every.six.months..The.swivel.jack’s.inner.
ram.should.be.lubricated.with.SAE.30.weight.oil..The.
top.cover.may.be.removed.to.lubricate.the.gears.with.
wheel.bearing.grease..
Replace.frayed.or.damaged.tie-downs..Periodically,.
lubricate the ratchet mechanism with a fine oil or
silicone.spray..Replacement.parts.may.be.ordered.
through.a.Four.Winns.dealer.
H. Wheels
Replace.all.worn.and.damaged.parts..ALWAYS.use.
the.manufacturer’s.replacement.parts..Replacement.
parts.may.be.ordered.through.your.Four.Winns.dealer..
Some maintenance is required to maintain the finish
and.retard.rusting.of.painted.rims..The.wheels.should.
be.cleaned.with.dishwashing.soap.and.water.and.
rinsed.with.clean.water.immediately.after.each.use...
Waxing.is.recommended.three.to.four.times.each.
year..
For.more.information.on.maintenance,.refer.to.the.
manufacturer’s.literature.included.in.the.owner’s.
packet.
D. Brake Actuator & Coupling Assembly
Aluminum.wheel.rims.may.be.cleaned.with.dishwas-
hing.soap.and.water..However,.cleaning.products.
specifically for aluminum are available and can be
used..Cleaners.may.be.obtained.from.Four.Winns.
dealers.and.your.local.auto.parts.stores..The.Mag.
wheel.manufacturer.recommends.a.product.by.Prior-
®
ity.One .called.Pro-Long.Aluminum/Chrome.Wheel.
Protectant™. Galvanized rims should be rinsed only
with.clean.water.immediately.after.each.use.
When.storing.or.parking.your.trailer,.keep.the.brake.
actuator.and.coupling.assembly.(coupler).off.the.
ground.to.prevent.dirt.buildup.in.the.ball.socket..Keep.
the.coupler.clean.of.dirt,.tar,.and.mud..Lubricate.the.
coupler.with.SAE.30.weight.oil.every.six.months.or.as.
often.as.necessary..Replace.any.worn.or.defective.
parts..If.the.coupler.is.damaged,.contact.your.Four.
Winns.dealer.for.replacement.parts..DO.NOT.use.a.
damaged.or.bent.coupler.assembly..For.more.infor-
mation.on.maintenance,.refer.to.the.manufacturer’s.
literature.included.in.the.owner’s.packet.
NOTICE
ALWAYS read the manufacturer’s instructions
on the label before using any product.
NOTICE
The trailer should be set up at a slight angle to
allow for water to drain aft in the boat.
I.
Brakes
Keep.the.actuator.clean.of.dirt,.tar,.and.mud..The.
actuator.and.internal.parts.should.be.lubricated.at.all.
times.with.SAE.30.weight.oil..The.hitch.ball.may.be.
lubricated.with.automotive.grease.or.lubricant.made.
for.hitch.balls.
E. Winch
.
The.winch.should.be.kept.clean.of.dirt,.ice,.paint,.
etc., and the spur gears should have a film of grease
on.them.at.all.times..Apply.several.drops.of.SAE.30.
weight.oil.to.the.ratchet.pawl.mechanism,.bushings.
and.pinion.shaft.threads.twice.per.season...
Periodically.inspect.the.brake.system.for.leaks...
Check.all.hoses.for.cuts.or.wear..Replace.all.defective.
hoses. The master cylinder should be filled within 1/2
inch.from.the.top.of.the.reservoir.
Replace.any.worn.or.damaged.parts..For.more.infor-
mation.on.maintenance,.refer.to.the.manufacturer’s.
literature.included.in.the.owner’s.packet.
.
At.the.beginning.of.each.year,.inspect.the.brakes.for.
excessive.wear,.have.linings.replaced.if.necessary...
F. Lights
If.the.brakes.need.bleeding,.consult.your.Four.Winns.
dealer.for.assistance..If.unavailable,.a.brake.or.auto.
repair.facility.can.perform.the.repair.
Inspect.wiring.for.cuts.or.bare.wire.which.could.cause.
electrical.shorts..Repair.or.replace.defective.wiring..
Replace.cracked.or.damaged.lens.and.always.carry.
spare.bulbs..Replacement.parts.may.be.ordered.
through.a.Four.Winns.dealer.
Refer.to.the.manufacturer’s.literature.included.in.the.
owner’s.packet.for.additional.information.on.the.brake.
system.
Trailer Information - Section S
Owner’s Manual Page
| Categories | Four Winns Funship Manuals, Four Winns Manuals, Outboard Marine Corporation Manuals |
|---|---|
| Tags | Four Winns Funship 194, Four Winns Funship 204, Four Winns Funship 214, Four Winns Funship 224, Four Winns Funship 234, Four Winns Funship 244, Four Winns Funship 264, Four Winns Funship 274 |
| Model Year | 2006, 2007, 2008 |
| Download File |
|
| Document Type | Owner's Manual |
| Language | English |
| Product Brand | Boats and Cruisers, Four Winns. For support contact your dealer at http://www.fourwinns.com/locate-dealer.aspx |
| Document File Type | |
| Publisher | fourwinns.com |
| Wikipedia's Page | Outboard Marine Corporation |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)