Whenever running the engine, assure there
is proper ventilation to avoid carbon monox-
ide (CO), which is odorless, colorless, and
tasteless, and can lead to unconsciousness,
brain damage, or death if inhaled in sufficient
concentrations. CO accumulation can occur
while docked, anchored, or underway, and in
many confined areas such as the boat cabin,
cockpit, swim platform, and heads. It can be
worsened or caused by weather, mooring
and operating conditions, and other boats.
Avoid exhaust fumes from your engine or oth-
er boats, provide proper ventilation, shut off
your engine when not needed, and be aware
of the risk of backdrafting and conditions that
create CO accumulation. In high concentra-
tions, CO can be fatal within minutes. Lower
concentrations are just as lethal over long pe-
riods of time.
Do not operate your boat if you are under the
influence of drugs or alcohol.
High performance boats have a high power-
to-weight ratio. If you are not experienced in
the operation of a high performance boat, do
not attempt to operate one at, or near, its top
speed until you have gained that experience.
For more information, see your Evinrude/
Johnson DEALER for a copy of Introduction
to High Performance Boating, P/N 335763.
SAFETY MEASURES — Installation and
Maintenance
Outboard Installation
The outboard must be correctly installed.
Failure to correctly install the outboard could
result in serious injury, death or property
damage. We strongly recommend that your
DEALER install your outboard to ensure
proper installation.
Proceed with caution and at very low speed
in shallow water. Grounding or abrupt stops
may result in injury. Also be alert for debris
and objects in the water.
Be familiar with the waters you are operating
in. The gearcase of this outboard extends be-
low the water surface and could potentially
come in contact with underwater obstruc-
tions. Contact with underwater obstructions
may result in loss of control and personal in-
jury.
Do not overpower your boat by using an en-
gine that exceeds the horsepower indicated
on the boat’s capacity plate. Overpowering
could result in loss of control. If your boat has
no capacity plate, contact your DEALER or
the boat’s manufacturer.
Maintenance
Avoid standing up or shifting weight suddenly
in light weight boats.
When replacement parts are required, use
Evinrude®/Johnson® Genuine Parts or parts
with equivalent characteristics, including
type, strength and material. Using substan-
dard parts could result in injury or product
malfunction.
Keep your passengers seated in seats. The
boat’s bow, gunwale, transom and seat
backs are not intended for use as seats.
Insist on the use of personal flotation devices,
approved by the U.S. Coast Guard, by all
passengers when boating conditions are
hazardous, and by children and nonswim-
mers at all times.
Only perform service procedures which are
detailed in this Operator’s Guide. Attempting
to perform maintenance or repair on your out-
board if you are not familiar with the correct
service and safety procedure could cause
personal injury or death. Further information
can be obtained from your authorized
Evinrude/Johnson DEALER. In many in-
stances proper tools and training are required
for certain service or repair procedures.
Respect no wake zones, rights of other water
users and the environment. As the "skipper"
and owner of a boat you are responsible for
damage to other boats caused by the wake of
your boat. Allow no one to throw refuse over-
board.
Maintain your boat and engine in top condi-
tion at all times. Adhere to the Engine Main-
tenance and Inspection Schedule.
Know the marine traffic laws and obey them.
Remember, gasoline fumes are flammable
and explosive. Always adhere to the fueling
procedure contained in this Operator’s Guide
and those given to you by the fueling station.
Always verify fuel level before use and during
the ride. Apply the principle of 1/3 fuel to des-
tination, 1/3 back and 1/3 reserve fuel supply.
Do not carry spare fuel or flammable liquids
in any storage or engine compartments.
Operate your boat and outboard prudently
and have fun. Do not forget that all persons
must assist other boaters in case of emer-
gency.
Prevent injury from contact with rotating pro-
peller; remove propeller before flushing or
before performing any maintenance.
General Information - 3
| Categories | BRP Brand Manuals, Johnson 4-Stroke Manuals, Johnson Brand Manuals, Johnson Outboard Manuals |
|---|---|
| Tags | Johnson 15 hp, Johnson 9.9 hp, Johnson R4, Johnson RL4 |
| Model Year | 2004 |
| Download File |
|
| Document File Type | |
| Copyright | Attribution Non-commercial |
(1 votes, average: 5 out of 5)
Marine readers have rated 2004 Johnson 9.9 15 hp R4 RL4 4-Stroke Outboard Owners Manual 5.0 out of 5.0 based on 1 product reviews.