Check your battery terminals frequently for corrosion and tightness. Clean terminals with a baking soda and
water solution and a wire brush. Also, check the fluid levels in the cells. Usually, a level approximately 1/4
to 1/2 inch above the plates is sufficient. If needed, fill with distilled water. However, some batteries are
sealed, and this process is not necessary. Also, read directions when applicable.
:$51,1*
Malibu does not recommend starting your engine with jumper cables under any circumstances.
Risk of spark at the battery post igniting gasoline fumes or hydrogen gas from the battery is too
great.
(QJLQH&DUH
For information on engine service and maintenance, please refer to your engine owner's manual. The
maintenance schedule included in this manual outlines safety checks, lubrication, and general service, that
should be performed at regular intervals. It is recommended that any engine replacement parts used for
maintenance or repair be supplied by an authorized Malibu dealer.
5XGGHU6WXIILQJ%R[
The rudder stuffing box has a grease nipple and should be checked and lubricated annually. The rudder
stuffing box is accessed through the rear center access panel. Use only a waterproof grease.
:LQWHUL]LQJ
When the boating and ski season comes to an end, it is recommended that the boat be removed from the
water and stored. It is extremely important that proper winterizing procedures are read and followed to
ensure longer boat life. Here is our list of suggestions to keep your boat in top condition:
1.
2.
3.
4.
Prepare the engine according to the instructions found in your engine owner's manual.
Clean and dry the boat's interior and exterior thoroughly.
Inspect boat hull for residue and remove any if present.
Clean the bilge area thoroughly and operate the bilge pump to remove any water from bilge
lines.
5.
Remove all seat cushions and open all storage areas. Store the seat cushions in a cool and
dry place.
6.
7.
Cover the boat and store it in a garage or other protected facility.
If the boat is stored on a trailer, you should block the trailer wheels.
([WHULRU
Your Malibu boat is highly resistant to weathering, water pollution, and minor scrapes which occur during
normal use. However, regular care and maintenance of your boat is a general responsibility for all Malibu
boat owners. By following the boat care instructions listed below, you will be able to extend the life and
beauty of your Malibu boat.
)LEHUJODVVDQG*HOFRDW
The fiberglass hull and deck of your Malibu boat consist of a molded shell and exterior gelcoat. The gelcoat
protects the fiberglass shell and gives all Malibu boats a smooth and shiny surface. The following are some
general instructions which will help you maintain your boat's sleek appearance:
1.
Wash monthly or more frequently, depending on use. Use a mild dishwashing soap and wash in
lukewarm or cold water. Rinse your boat with fresh water and wipe down immediately to avoid
water spots.
27
| Categories | Malibu Manuals |
|---|---|
| Model Year | 1993, 1994, 1995, 1996 |
| Download File |
|
| Document File Type | |
| Copyright | Attribution Non-commercial |
(2 votes, average: 4.5 out of 5)
Marine readers have rated Malibu Boats Operation and Maintenance Manual 4.5 out of 5.0 based on 2 product reviews. 4 stars...need info on how to operate a Malibu 20 footer.
nice manual