Operation
quarter throttle or less to let the engine
cool.
4.
5.
Remaining seven hours:
Run the engine at any speed. However,
avoid operating at full throttle for more
than 5 minutes at a time.
After the first 10 hours:
Operate the engine normally.
EMU27103
Preoperation checks
EWM00080
WARNING
If any item in the preoperation check is
not working properly, have it inspected
and repaired before operating the out-
board
motor. Otherwise an accident
could occur.
ECM00120
CAUTION:
Do not start the engine out of water. Over-
heating and serious engine damage can
occur.
ZMU01945
EMU27091
Procedure for HPDI models
Run the engine under load (in gear with a
propeller installed) for 10 hours as follows.
EMU31550
Fuel
1.
2.
First 10 minutes:
q Check to be sure you have plenty of fuel
for your trip.
q Make sure there are no fuel leaks or gaso-
line fumes.
Run the engine at the lowest possible
speed. A fast idle in neutral is best.
Next 50 minutes:
Do not exceed half throttle (approxi- q Check fuel line connections to be sure they
mately 3000 r/min). Vary engine speed
are tight (if equipped Yamaha fuel tank or
occasionally. If you have an easy-plan-
boat tank).
ing boat, accelerate at full throttle onto q Be sure the fuel tank is positioned on a se-
plane, then immediately reduce the
throttle to 3000 r/min or less.
Next two hours:
cure, flat surface, and that the fuel line is
not twisted or flattened, or likely to contact
sharp objects (if equipped Yamaha fuel
tank or boat tank).
3.
Accelerate at full throttle onto plane,
then reduce engine speed to three-quar- q Check the water in the fuel filter with the
ter throttle (approximately 4000 r/min).
Vary engine speed occasionally. Run at
full throttle for one minute, then allow
about 10 minutes of operation at three-
water separator warning device. Place the
gear shift lever in neutral and turn the main
switch to “ ”(on). If the buzzer sounds
and the water separator warning indicator
38
| Categories | Yamaha Outboard Manuals |
|---|---|
| Document Type | Boat Motor Manual Free Download. Marine Operator's Boating Guide. |
| Tags | Yamaha LZ300, Yamaha Z300 |
| Model Year | 2007 |
| Download File |
|
| Language | English |
| Product Brand | Yamaha Motor. Yamaha Motor Corporation, USA - Support Customer Relations for US: 1-800-962-7926
Yamaha Boats: 1-800-962-7926 Yamaha Outboard Customer Relations: 1-866-894-1626 , Yamaha Outboard |
| Document File Type | |
| Publisher | yamaha-motor.com |
| Wikipedia's Page | Yamaha Motor Company |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)