against.the.steering.cable.at.the.back.of.the.boat...
The.cable.must.be.free.and.clear.to.slide.back.and.
forth..Any.item.blocking.free.movement.of.the.cable.
will.result.in.harder.steering.and.possible.damage..
to.the.steering.cable..
G - 2 PROPELLER TORQUE
The.propeller.rotation.of.a.single.engine.operation.will.
exert.a.directional.force.on.the.steering.system..
Propeller.torque.can.also.cause.the.boat.to.wander.
(not.follow.a.straight.line).when.operated.at.low.speeds..
This.condition.is.normal.and.can.be.corrected.only.by.
increasing.engine.RPM..Wind,.water.currents.and.play.
in.steering.components.can.cause.equivalent.effects.
If.the.power.steering.system.cannot.be.corrected.on.
board,.proceed.at.a.reduced.speed..The.boat.will.be.
steerable,.but.with.increased.effort..Return.the.boat..
to.your.Four.Winns.dealer.as.soon.as.possible.to.
correct.the.power.steering.system.
Steering effort can vary significantly with
engine acceleration, steering angle, trim angle,
and sea condition. Be prepared for additional
steering loads at all times.
Check the power steering fluid level in the
reservoir periodically. Low power steering fluid
levels may increase steering difficulty.
G - 3 STEERING SYSTEM MAINTENANCE
A. General Maintenance
After the first two hours of running time, check
the entire steering system for loose bolts, nuts
and fasteners which could adversely affect
steering control.
A.periodic.inspection.of.all.steering.cables,.linkage.
and.helm.assemblies.should.be.made..Signs.of.
corrosion,.cracking,.loosening.of.fastenings,.excessive.
wear,.or.deterioration.should.be.immediately.correct-
ed..Failure.to.do.so.could.lead.to.steering.system.
failure.and.corresponding.loss.of.control.
NOTICE
When storing equipment in the engine com-
partment, be sure to avoid contact with the
steering cable. Cables may become kinked or
damaged and may increase steering effort.
NOTICE
Check all bolts, nuts and fasteners for tightness.
NOTICE
B. Rotary System Maintenance
DO NOT force the steering unit to either ex-
treme. This can place undue strain on the unit
and can lead to hydraulic line or seal failure.
The.helm.and.cable.assembly.should.be.so.adjusted.
that.the.steering.wheel.is.centered.with.the.drive.or.
outboard.engine.in.the.straight.ahead.position..There.
should.be.an.equal.number.of.turns.to.port.and.
starboard.from.the.straight.ahead.position..If.adjust-
ment.becomes.necessary,.see.your.Four.Winns.
dealer.
It is important that the power steering fluid be main-
tained at the proper level. Do not over fill the power
steering.pump.reservoir..Please.consult.the.section.
in.the.engine.manual.regarding.steering.system.and.
maintenance..The.engine.manual.is.included.in.the.
owner’s.packet..
Check.all.metal.parts.at.the.cable.output.end.for.
corrosion..Remove.any.old.grease.from.the.cable..
ram.and.motor.swivel.connections.using.a.mild.
solvent.such.as.WD-40..Spray.the.cleaned.areas..
with.a.moisture-displacing.lubricant.and.apply.a.light.
coat.of.good.quality.marine.grease..Do.this.with.the.
ram.fully.extended..See.Figure.G3.
Steering Systems - Section G
Owner’s Manual Page
| Categories | Four Winns Manuals, Four Winns Vista Manuals, Outboard Marine Corporation Manuals |
|---|---|
| Tags | Four Winns Horizon 310 |
| Model Year | 2007, 2008 |
| Download File |
|
| Document Type | Owner's Manual |
| Language | English |
| Product Brand | Boats and Cruisers, Four Winns. For support contact your dealer at http://www.fourwinns.com/locate-dealer.aspx |
| Document File Type | |
| Publisher | fourwinns.com |
| Wikipedia's Page | Outboard Marine Corporation |
| Copyright | Attribution Non-commercial |
(0 votes, average: 0 out of 5)