Steering Systems
G - 1 GENERAL
B. Rotary Steering
The.stern.drive.Vista
®
.models.are.equipped.with.
In.the.rotary.system,.a.rotary.drum.assembly.is.
mounted.under.the.dash.behind.the.steering.wheel...
A.one.piece.cable.runs.from.the.drum.assembly.
through.the.boat.into.the.engine.compartment...
At.the.transom,.the.cable.turns.and.is.connected..
to.the.drive.tiller.and.the.power.steering.unit..
rotary-type.steering.systems..A.tilt.steering.wheel.is.
®
standard.on.the.318.Vista .models..
A. Tilt Steering
The.steering.wheel.can.be.tilted.up.or.down.so.as.to.
enhance.the.driver’s.comfort.and.enjoyment..To.tilt.the. C. Power Steering
steering.wheel,.depress.the.release.lever.with.your.
thumb..See.Figure.G-1..Be.sure.to.hold.the.top.of.the.
wheel.to.assist.in.positioning..Refer.to.the.steering.
manufacturer’s.literature.for.additional.information.
Power.steering.is.standard.engine.equipment.on..
®
stern.drive.Vista .models..It.is.comprised.of.an.engine.
mounted.pump,.control.valve,.hoses,.and.steering.
cylinder..Power.steering.works.in.conjunction.with.the.
helm.and.steering.cable.to.move.the.transom.mount-
ed.tiller.arm.and.vertical.drive.more.easily.
On.twin.engine.installations,.only.the.starboard.engine.
is.equipped.with.a.power.steering.hydraulic.assist.unit..
Therefore,.when.operating.on.a.single.engine,.it.is.
imperative.to.operate.with.the.starboard.engine..If.only.
the.port.engine.is.used,.hard.steering.will.result.
NOTICE
DO NOT force the steering wheel to either
extreme position. This can place undue strain
on the unit and can lead to power steering
damage.
Upon.commissioning.the.boat,.it.is.necessary.to..
purge.the.system.of.air..This.is.performed.by.your.
Four.Winns.dealer.during.pre-delivery.service...
Should steering difficulty increase with time, it is
possible.additional.bleeding.of.the.system.is.required..
See.your.Four.Winns.dealer.for.assistance..This.and.
other.adjustments.on.power.steering.units.are.critical.
and should be performed only by a qualified service
technician.
Figure G-1: Tilt Steering
The tilt mechanism should not be adjusted
when the boat is moving. Sudden boat move-
ment may cause loss of balance resulting in
loss of control and/or injury.
If.the.power.steering.becomes.inoperative,.steering.
will.be.harder.and.more.effort.will.be.needed.to.steer.
the.boat..Check.for.a.broken.or.loose.belt.on.the.
power steering pump. Also, low fluid levels in the
power.steering.pump.reservoir.will.cause.hard.steer-
ing..If.these.items.are.not.the.source.of.the.problem,.
check.for.equip-ment.or.other.items.lying.on.or.up.
against.the.steering.cable.at.the.back.of.the.boat..
The.cable.must.be.free.and.clear.to.slide.back.and.
forth..Any.item.blocking.free.movement.of.the.cable.
will.result.in.harder.steering.and.possible.damage.to.
the.steering.cable..If.unable.to.locate.or.correct.the.
problem,.have.the.steering.cable.inspected.and.
lubricated.by.your.Four.Winns.dealer.
The tilt mechanism is spring loaded. Due to the
variation in steering wheel offerings, the wheel
may spring up rapidly when depressing the
release lever. ALWAYS KEEP ONE HAND ON
THE WHEEL DURING TILT ADJUSTMENT
OR INJURY MAY OCCUR.
Steering Systems - Section G
Owner’s Manual Page
Categories | Four Winns Manuals, Four Winns Vista Manuals, Outboard Marine Corporation Manuals |
---|---|
Tags | Four Winns Vista 318 |
Model Year | 2006, 2007, 2008 |
Download File |
|
Document Type | Owner's Manual |
Language | English |
Product Brand | Boats and Cruisers, Four Winns. For support contact your dealer at http://www.fourwinns.com/locate-dealer.aspx |
Document File Type | |
Publisher | fourwinns.com |
Wikipedia's Page | Outboard Marine Corporation |
Copyright | Attribution Non-commercial |
(1 votes, average: 5 out of 5) Marine readers have rated 2006-2008 Four Winns Vista 318 Boat Owners Manual 5.0 out of 5.0 based on 1 product reviews.