PROPELLER SELECTION
To select the correct propeller for your boating ap-
plication, your boat and motor MUST be water test-
ed. See your DEALER for assistance.
Refer to Propeller, before removing or installing
propeller.
IMPORTANT: The correct propeller for your boat,
under normal load conditions, will allow the engine
to run near the midpoint of the RPM operating
range at full throttle. Refer to Engine Specifica-
tions.
MOORING
3)
4)
5)
Place the remote control lever in NEUTRAL
with the propeller removed.
Start the water — keep pressure between 20
to 40 psi (140 to 300 kPa).
Start the engine — run it at idle only and
flush it for at least five minutes. Check the
water pump indicator. A steady stream of wa-
ter must flow. If it does not, shut OFF the en-
gine and investigate. Refer to Engine
Overheating.
You may moor your boat with the motor’s gearcase
out of the water by using its tilt feature. Depending
on the model, refer to Tilt Support or Power Trim
and Tilt.
FLUSHING
DANGER
6)
7)
Shut OFF the engine and remove the flusher.
Install the plug.
Leave the outboard in vertical position long
enough to completely drain the powerhead.
DO NOT run the engine indoors or without
adequate ventilation or permit exhaust
fumes to accumulate in confined areas.
Engine exhaust contains carbon monoxide
which, if inhaled, can cause serious brain
damage or death.
See your DEALER for a flushing device designed to
fit your engine. Follow manufacturer’s instructions
for installing and using it.
Outboard — Running
WARNING
Prevent injury from contact with rotating
propeller; remove the propeller before
flushing.
1)
2)
Place the engine in vertical position in a well-
ventilated area with good drainage.
Install flushing device and garden hose.
Operation - 29
| Categories | BRP Brand Manuals, Johnson 4-Stroke Manuals, Johnson Brand Manuals, Johnson Outboard Manuals |
|---|---|
| Document Type | Boat Motor Manual. Marine Operator's Engine Parts Boating Guide in PDF |
| Tags | Johnson 60 hp, Johnson PL4, Johnson70 hp |
| Model Year | 2004 |
| Download File |
|
| Document File Type | |
| Publisher | johnson.com |
| Copyright | Attribution Non-commercial |
(1 votes, average: 3 out of 3)
Marine readers have rated 2004 Johnson 60 70 hp PL4 4-Stroke Outboard Owners Manual 3.0 out of 3.0 based on 1 product reviews. A god and reliable fine little engine