CRANKCASE OIL AND FILTER
Initial Fill
Changing the Filter
1)
Remove the upper engine cover, the aft cov-
er latch and the port lower engine cover.
IMPORTANT: 4-Stroke outboards are shipped
without oil in the crankcase. You must add oil to
the crankcase before starting the engine for the
first time. It is recommended you add Evinrude/
Johnson 4-Stroke outboard oil. Refer to Changing
the Oil for acceptable substitute lubricants.
1
BEFORE filling the crankcase for the first time, be
sure it is empty by checking the dipstick. Refer to
Checking.
After the first 10 hours of operation, replace the
break-in lubricant with Evinrude/Johnson ultra 4-
Stroke synthetic blend oil. Refer to 10-Hour In-
spection.
1.
Port lower engine cover screws
Checking
2)
Place a rag under the oil filter on the engine.
Remove the filter by turning it countercloock-
wise.
Use clean oil to lubricate the gasket on a new
oil filter. Make sure the filter gasket is firmly
seated in its groove.
Install the filter and tighten 2/3 of a revolution
after the gasket contacts base. Hand tighten
only. Remove rag and any spilled oil.
Check the oil level when the engine is cold to en-
sure an accurate reading.
1)
2)
3)
Place the engine in a vertical position and re-
move the upper engine cover.
Remove the dipstick, wipe it clean, and install
3)
4)
it.
Move the dipstick again and locate the line of
oil. If the line of oil is not between the ADD
and the FULL marks, you must add or re-
move oil as indicated.
1
2
5)
Reinstall the lower engine cover, latch and
the upper engine cover.
1.
2.
Add
Full
4)
Securely install the dipstick and wipe up any
spilled oil.
IMPORTANT: Operating the engine with too much
or too little oil in the crankcase will damage it.
40
- Maintenance
| Categories | BRP Brand Manuals, Johnson 4-Stroke Manuals, Johnson Brand Manuals, Johnson Outboard Manuals |
|---|---|
| Tags | Johnson 40 hp, Johnson 50 hp, Johnson PL4 |
| Model Year | 2004 |
| Download File |
|
| Document File Type | |
| Copyright | Attribution Non-commercial |
(2 votes, average: 3.5 out of 4)
Marine readers have rated 2004 Johnson 40 50 hp PL4 4-Stroke Outboard Owners Manual 3.5 out of 4.0 based on 2 product reviews. F49 HP four Stromae 2004
J’aimerais avoir le livre d’entretien SVP (Francais si possible )
Merci
jkhinkic p pojem ppo pom apsm o0km, wp pem p-keoeok[po poe;me, c;